Product ID:D-701 NF DEVELOPER
MSDS Date:10/21/1986
FSC:6850
NIIN:00-145-0255
Kit Part:Y
MSDS Number: BDCFZ

MET-L-CHEK COMPANY

1639 EUCLID ST
SANTA MONICA, CA 90404
US

Emergency Phone: 310

Info Phone: 213-450-1111

Cage: 98733

MET-L-CHEK COMPANY

00000 SANTA MONICA, CA 90404 US

Telephone: 310-450-1111/FAX 310452-4046

Cage: 98733

METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)

CAS: 71-55-6

RTECS: KJ2975000

Fraction By Weight: <95.00%

OSHA PEL 350 PPM/450 STEL

ACGIH TLV: 350 PPM/450STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ISOBUTANE AND PROPANE MIXTURE (USED AS PROPELLANT)

CAS: 64742-95-6

Fraction By Weight: >5.00%

OSHA PEL 1000PPM (PROPANE)

ACGIH TLV: ASPHYXIANTS

METHYL SALYCILATE

CAS: 119-36-8

RTECS: VO4725000

Fraction By Weight: <5%

OSHA PEL NONE

ACGIH TLV: NONE

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:MATERIAL IS PRIMARILY CNS DEPRESSANT.
INHALATION CAN CAUSE IRRITATION OF RESP TRACT SYSTEM.SKIN OR EYES
CONTACT MAY RESULT IN DISCOMFORT,PAIN AND IRRITATION.SWALLOWING MAY
RESULT IN IRRITATION OF THE MOUTH AND GI TRACT.
Effects of Overexposure:EYES:MAY CAUSE IRRITATION; SKIN:SLIGHT
IRRITATION ON CONTACT WITH LIQUID.MAY CAUSE DERMATITIS;
INHALATION:VAPORS MAY IRRITATE RESP TRACT.CAUSES DIZZ, &
HEADACHE.PROGRESSIVELY HIGHER EXPOSURE OVER 1000 PPM CAN CAUSE CNS
DEPRESSION,UNCONSCIOUSNESS OR EVEN DEATH; INGESTION:MAY RESULT IN
MOUTH IRRIT AND VOMITING.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT. MAY CAUSE
DERMATITIS.

First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES.GET MEDICAL
HELP IF IRRITATION OCCURS OR PERSISTS; SKIN:FLUSH WITH WATER.WASH
WITH LUKE WARM WATER & SOAP.GET MEDICAL HELP FOR PERSISTING
IRRITATION; INHA LATION:REMOVE TO FRESH AIR.PROVIDE OXYGEN IF
BREATHING IS DIFFICULT.GET MED ASST IF NEEDED; INGESTION:IF
SWALLOWED,DO NOT INDUCE VOMITING.IF CONSCIOUS GIVE LARGE AMOUNT OF
WATER.GET MEDICAL ASSISTANCE

Flash Point:NONE
Lower Limits:7.0 %
Upper Limits:15.0 %
Extinguishing Media:PER MFR,USE WATER,DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH-APPROVED PRESSURE DEMAND
SELF-CONTAINED BREATHING APPARATUS. COOL CANS WITH WATER SPRAY TO
PREVENT BUILT-UP OF INTERNAL VAP PRESSURE IN AEROSOL CANS.
Unusual Fire/Explosion Hazard:AEROSOL CANS MAY RUPTURE/EXPLODE DUE TO
VAP PRESSURE BUILDUP IN INTESE HEAT.IN CONFINED AREA VAPORS CAN BE
IGNITED UPON CONTACT W. HIGH ENERGY SPARK/FLAME/HEAT.

Spill Release Procedures:ELIMINATE IGNITION SOURCES.PROVIDE MAX
VENTILATION.WEAR EYE,SKIN,AND RESPIRATORY PROTECTION.SOAK UP WITH
ABSORBENT SUCH AS SAW DUST OR VERMICULITE.SWEEP UP AREA. AVOID
DUSTING.KEEP WASTE IN SEALED CON TAINERS PENDING DISPOAL
INSTRUCTIONS.DONOT FLUSH.

Handling and Storage Precautions:KEEP AWAY FROM SOURCE OF
HEAT/IGNITION.STORE IN COOL,DRY & VENTILATED AREA.DO NOT STORE NEAR
OXIDIZING MATERIAL;AVOID PHYSICAL DAMAGE TO CONTAINERS.
Other Precautions:MINIMIZE SKIN CONTACT.AVOID BREATHING VAPORS.USE ONLY
WITH ADEQUATE VENTILATION.AVOID PROLONGED & REPEATED CONTACT WITH
SKIN.DO NOT SWALLOW.VAPORS ARE HEAVIER THAN AIR WILL COLLECT IN LOW
AREAS.DO NOT ENTER WITHOUT RESPIRATORY PROTECTION.

Respiratory Protection:NOT NEEDED IN NORMAL CONDITIONS OR USES WHEN
VAPORS/MIST CONCENTRATIONS ARE BELOW TLV/PEL LIMITS.WEAR NIOSH
APPROVED ORGANIC VAPOR CHEMICAL CARTRIDGE OR CANISTER TYPE
RESPIRATOR WHEN TLV EXCEEDS OR IN ABSENCE OF PROPER ENVIRONMENTAL
CONTROL
Ventilation:LOCAL EXHAUST OR MECHANICAL(GENERAL) TO MAINTAIN TLV OR
BELOW TLV LIMITS.
Protective Gloves:VITON
Eye Protection:SPLASH-PROOF GOGGLES
Other Protective Equipment:CHEMICAL RESISTANT APRON TO PREVENT
CLOTHING/SKIN CONTACT.
Work Hygienic Practices:WASH HANDS WITH SOAP & WATER BEFORE EATING,
SMOKING OR USING TOILET FACILITIES;DO NOT EAT/DRINK IN VAPOR
CONTMNTD AREA.
Supplemental Safety and Health
KEY1:F1. THIS PRODUCT IS A KIT CONSISTING OF THREE PARTS.
CLEANER/REMOVER HAS PNI C, PENETRANT HAS PNI A AND DEVELOPER HAS
PNI D, SAME NSN.

HCC:V3
Vapor Pres:135MM@25C
Vapor Density:4.54
Spec Gravity:1.300 TO 1.320
Evaporation Rate & Reference:0.35 (ETHYL ETHER = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:MILKY WHITE LIQUID BEFORE FILLING INTO
LIQ;ETHER-LIKE ODOR

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL,CAUSTIC SODA,CAUSTIC POTASH.
Stability Condition to Avoid:SOURCE OF HEAT/IGNITION. AVOID EXPOSURE TO
OXIDIZING MATERIALS.
Hazardous Decomposition Products:HYDROGEN CHLORIDE AND POSSIBLY TRACES
OF PHOSGENS.

Waste Disposal Methods:PER MANUFACTURER, THE WASTE MUST BE DISPOSED OF
IN A PERMITTED HAZARDOUS WASTE MANAGEMENT FACILITY IN FULL
COMPLIANCE WITH ALL FEDERAL STATE & LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.